Product ID:NOX RUST 501 LS (MIL-PRF-16173E, CLASS 1, GRADE 1)
MSDS Date:03/03/1997
FSC:8030
NIIN:00-244-1300
Status Code:A
MSDS Number: CLHZM

RALRUBE INC.

36977 FOX GLEN
FARMINGTON HILLS, MI 48331
US

Emergency Phone: (800)424-9300

Info Phone: 248-661-0260

Preparer: HENRY SIMMONS

Cage: 6X798

RALRUBE INC.

FARMINGTON HILLS, MI 48331 US

Telephone: 248-661-0260, FAX 248-661-3941

Cage: 6X798

PETROLEUM ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

ACGIH TLV: 5 MG/M3

ALIPHATIC PETROLEUM SOLVENT

CAS: 64742-88-7

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

HYDROGEN SULFIDE

CAS: 7783-06-4

RTECS: MX1225000

OSHA PEL see Table Z-2

ACGIH TLV: 14 MG/M3;10 PPM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPOR S MAY CAUSE
NOSE, THROAT, AND MUCOUS MEMBRANE IRRITATION, AND NAUSEA, HEADACHES
OR DIZZINESS, AND CENTRAL NERVOUS SYSTEM DEPRESSION, INCLUDING
DROWSINESS, LOSS OF COORDINATI ON, AND UNCONSCIOUSNESS. PROLONGED
OR REPEATED SKIN CONTACT WITH COLD PRODUCT AT RESULT IN DRYNESS AND
IRRITATION OF THE SKIN. PROLONGED CONTACT WITH CLOTHING SATURATED
IN PETROLEUM DISTILLATES CAN CA USE SECOND DEGREE BURNS. CHRONIC:
PROLONGED OR REPEATED SKIN CONTACT WITH THESE PRODUCTS MAY RESULT
IN IRRITATION AND DERMATITIS. STUDIES OF WORKERS EXPOSED TO ASPHALT
HAVE NOT ESTABLISHED AN ASSOCI ATION BETWEEN ASPHALT AND CANCER OR
LUNG
Explanation of Carcinogenicity:PETROLEUM ASPHALT. IN MARCH 1987, THE
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) CLASSIFIED
EXTRACTS OF STEAM AND AIR REFINED BITUMENS (SUCH AS MINERAL SPIRITS
CUTBACK ASPHALT) AS POSSIBLY CAR CINOGENIC TO HUMANS (GROUP 2B).
THIS CLASSIFICATION WAS BASED ON COMBINED EVALUATION OF PUBLISHED
HUMAN AND ANIMAL STUDIES.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY OR SKIN
CONDITIONS MAY WORSEN FROM EXPOSURE TO THESE PRODUCTS.

First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AND CALL MEDICAL CARE.
IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION; IF BREATHING IS
DIFFICULT, GIVE OXYGEN. EYES: IN CASE OF CONTACT WITH MATERIAL,
IMMEDIATEL Y FLUSH EYES WITH RUNNING WATER FOR AT LEAST 15 MINUTES.
SEEK IMMEDIATE MEDICAL ATTENTION. SKIN: WASH SKIN WITH SOAP AND
WATER. REMOVE AND ISOLATE CONTAMINATED CLOTHING AND SHOES AT THE
SITE. INGES TION: DO NOT INDUCE VOMITING. CONSULT A PHYSICIAN. IF
VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION INTO THE LUNGS.

Flash Point:=40.6C, 105.F
Lower Limits:0.5
Upper Limits:7.0
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, WATER SPRAY, OR
REGULAR FOAM. LARGE FIRES: WATER SPRAY, FOG, OR REGULAR FOAM. MOVE
CONTAINER FROM FIRE AREA IF YOU CAN DO IT WITHOUT RISK.
Fire Fighting Procedures:FIRE MAY PRODUCE IRRITATING OR POISONOUS
GASES. POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA)
AND STRUCTURAL FIREFIGHTERS? PROTECTIVE CLOTHING WILL PROVIDE
LIMITES PROTECTION. KEEP UNNEC ESSARY PEOPLE AWAY. ISOLATE HAZARD
AREA AND DENY ENTRY. STAY UPWIND; KEEP OUT OF LOW AREAS. ISOLATE
FOR ? MILE.
Unusual Fire/Explosion Hazard:FLAMMABLE/COMBUSTIBLE MATERIAL. MAY BE
IGNITED BY HEAT, SPARKS, OR FLAMES. VAPORS MAY TRAVEL TO A SOURCE
OF IGNITION AND FLASH BACK CONTAINER MAY EXPLODE IN HEAT OF FIRE.
VAPOR EXPLOSION HAZARD INDOOR S, OUTDOORS, OR IN SEWERS. RUNOFF TO
SEWER MAY CREATE FIRE OR EXPLOSION HAZARD.

Spill Release Procedures:SHUT OFF IGNITION SOURCES; NO FLARES; SMOKING
OR FLAMES IN HAZARD AREA. STOP LEAK IF YOU CAN DO IT WITHOUT RISK.
LARGE SPILLS: TAKE UP WITH SAND OR OTHER NONCOMBUSTIBLE ABSORBENT
AND PLACE INTO CONTA INERS FOR LATER DISPOSAL. SMALL SPILLS. DIKE
FAR AHEAD OF LIQUID SPILL FOR LATER DISPOSAL.

Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA.
KEEP AWAY FROM FLAMES, SPARKS OR HOT SURFACES. NEVER USE A TORCH TO
CUT OR WELD ON OR NEAR CONTAINER. EMPTY CONTAINER CAN CONTAIN
EXPLOSIVE VAPORS. HEATED ASPHALT MAY EMIT HYDROGEN SULFIDE, AN
EXTREMELY FLAMMABLE, COLORLESS, HIGHLY TOXIC GAS.
Other Precautions:NEVER WEAR CONTAMINATED CLOTHING. LAUNDER OR DRY
CLEAN AREA BEFORE WEARING. DISCARD OIL-SOAKED SHOES. WASH
THOROUGHLY WITH SOAP AND WATER (WATERLESS HAND CLEANER MAY BE
HELPFUL IN REMOVING IN REMOVING RESIDUES) AFTER USE AND BEFORE
SMOKING OR HEATING. AVOID EXCESSIVE SKIN CONTACT.

Respiratory Protection:NIOSH-APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
TO MIST TO CONTROL EXPOSURE WHERE VENTILATION IS INADEQUATE. IN
SITUATIONS WERE HYDROGEN SULPHIDE MAY EXCEED, THE PEL OR TLV,
SUPPLIED AIR RESPIRATORS O R SELF-CONTAINED BREATHING APPARATUS?
ARE REQUIRED.
Ventilation:GENERAL AND LOCAL EXHAUST.
Protective Gloves:IMPERVIOUS GLOVES (VITON, PVOH)
Eye Protection:SAFETY GLASSES WITH SIDESHIELDS OR CHEMICAL GOGGLES.
Other Protective Equipment:IF SPLASHING IS ANTICIPATED, WEAR RUBBER
APRON AND BOOTS OR OTHER PROTECTIVE EQUIPMENT TO MINIMIZE CONTACT.
Work Hygienic Practices:HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL
HYGIENE AND SAFETY PRACTICES. THESE INCLUDE AVOIDING ANY
UNNECESSARY EXPOSURE AND REMOVAL OF THE MATERIAL FROM THE SKIN,
EYES AND CLOTHING.
Supplemental Safety and Health

Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK VISCOUS LIQUID AND A PETROLEUM SOLVENT ODOR.
Percent Volatiles by Volume:57

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
MISCELLANEOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE, LOCAL AND
FEDERAL REGULATIONS. MATERIALS MAY BECOME HAZARDOUS WASTE THROUGH
USE. IF PERMITTED, INCINERATION MAY BE PRACTICED. CONSIDER
RECYCLING SOLVENT.

SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING
EXTREMELY HAZARDOUS SUBSTANCES SUBJECT TO THE EMERGENCY PLANNING
UNDER SEC. 301-303 (40CFR PARTS 300 AND 355) AND EMERGENCY RELEASE
NOTIFICATION REQUIREMENTS. HYD ROGEN SULFIDE 7783-06-4 <0.08
100(FINAL RQ LBS)
Federal Regulatory Information:(CERLA LIST) THIS PRODUCT CONTAINS THE
FOLLOWING HAZARDOUS) SUBJECT TO EMERGENCY RELEASE NOTIFICATION
REQUIREMENTS UNDER SEC. 304 (40 CFR PART 302) ALIPHATIC PETROLEUM
SOLVENT 64742-88-7 AND/OR 8052-4 1-3 AND/OR 64742-47-8 48-53%
100(FINAL RQ LBS)
State Regulatory Information:CALIFORNIA PROPOSITION 65 THIS PRODUCT
CONTAINS TRACE QUANTITIES OF THE FOLLOWING CHEMICALS THAT ARE
IDENTIFIED BY A STATE OF CALIFORNIA UNDER THE SAFE DRINKING AND
TOXIC ENFORCEMENT OF 1986 (PROPOSIT ION 65) AS EITHER A
CARCINOGENIC OR REPRODUCTIVE HAZARD. PETROLEUM ASPHALT 8052-42-4
40-45%

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.